[1]肖 旸,尹 岚,马 砺,等.不同预氧化温度下煤样热物性参数的实验研究[J].西安科技大学学报,2018,(03):383-388.[doi:10.13800/j.cnki.xakjdxxb.2018.0306]
 XIAO Yang,YIN Lan,MA Li,et al.Experimental study on coal thermo-physical parameters under the different peroxidation temperature[J].Journal of Xi'an University of Science and Technology,2018,(03):383-388.[doi:10.13800/j.cnki.xakjdxxb.2018.0306]
点击复制

不同预氧化温度下煤样热物性参数的实验研究(/HTML)
分享到:

西安科技大学学报[ISSN:1672-9315/CN:61-1434/N]

卷:
期数:
2018年03期
页码:
383-388
栏目:
出版日期:
2018-05-15

文章信息/Info

Title:
Experimental study on coal thermo-physical parameters under the different peroxidation temperature
文章编号:
1672-9315(2018)03-0383-06
作者:
肖 旸12尹 岚12马 砺12周一峰12
1.西安科技大学,安全科学与工程学院,陕西 西安 710054; 2.西安科技大学,陕西省煤火灾害防治重点实验室,陕西 西安 710054
Author(s):
XIAO Yang12YIN Lan12MA Li12ZHOU Yi-feng12
(1.College of Safety Science and Engineering,Xi'an University of Science and Technology,Xi'an 710054,China; 2.Shaanxi Key Laboratory of Prevention and Control of Coal Fire,Xi'an University of Science and Technology,Xi'an 710054,China)
关键词:
热物性参数 程序升温 预氧化处理 温度 敏感性
Keywords:
thermo-physical parameters programmed-temperature pre-oxidation treatment temperature sensitivity
分类号:
TD 75
DOI:
10.13800/j.cnki.xakjdxxb.2018.0306
文献标志码:
A
摘要:
为了研究在不同预氧化温度下煤样热物性参数的变化规律,选取长焰煤进行热物性实验。首先通过程序升温氧化法对煤样进行预氧化处理,分别氧化升温至80,110,140,170,200 ℃.然后使用激光导热仪LFA 457装置测定在30~300 ℃温度范围内的煤样热物性参数,研究预氧化处理后煤样的热物性参数随温度的变化趋势,并分析预氧化处理后的煤样对温度的敏感性。结果表明:在30~300 ℃范围内,随着温度的升高,煤样的热扩散系数呈现出逐渐降低的趋势,而煤样的导热系数和比热容呈现出逐渐升高的趋势,并且温度越高,煤样的热扩散系数的降低趋势以及比热容和导热系数的增大趋势越来越平稳。在相同温度下,预氧化处理煤样的热物性参数均高于原煤样。从敏感性分析可知,比热容对温度最敏感,而导热系数的敏感性最低,且当温度超过120 ℃时,煤样的预氧化温度越高,其热物性参数对温度的敏感性越低。实验结果对于了解煤层自燃和火灾蔓延过程中的传热具有指导意义,为煤自燃的防治提供理论依据和技术指导。
Abstract:
To investigate the variation law of the thermo-physical parameters of coal samples under the different pre-oxidation temperature,temperature-programmed apparatus was selected to treat the long flame coal,the coal samples were pre-oxidized at 80,110,140,170 and 200 ℃,respectively.Then,laser flash apparatus LFA 457 was used to measure the thermo-physical parameters of coal samples in the range of 30 to 300 ℃,which investigated the variation tendency of thermo-physical parameters of coal samples with temperature after pre-oxidation treatment,and analyzed the sensitivity of it to temperature.The results indicate that in the range of 30 to 300 ℃,with the elevating temperature,the thermal diffusivity of coal samples presented a decreased tendency,the thermal conductivity and the specific heat capacity presented an increasing tendency.Temperature was higher,the decreasing tendency of thermal diffusivity and the increasing tendency of specific heat capacity and thermal conductivity would tend to be weaker.At the same temperature,the thermo-physical parameters of pre-oxidation coal samples were higher than raw coal.It is found from sensitivity analysis that the specific heat capacity was most sensitive to temperature,whereas the sensitivity of the thermal conductivity was lowest.When the temperature was over 120 ℃,the higher the pro-oxidation temperature,the lower the sensitivity of thermo-physical parameters to temperature.Those results are meaningful for understanding of heat transfer in coal seam during spontaneous combustion of coal and fire spread,and provide a theoretical basis and technical guidance for the prevention of coal spontaneous combustion.

参考文献/References:

[1] 邓 军,李 贝,王 凯,等.中国煤火灾害防治技术研究现状及展望[J].煤炭科学技术,2016,44(10):1-7,101. DENG Jun,LI Bei,WANG Kai,et al.Research status and prospect of coal fire disaster prevention technology in China[J].Coal Science and Technology,2016,44(10):1-7,101.
[2] 邓 军,李 贝,李珍宝,等.预报煤自燃的气体指标优选试验研究[J].煤炭科学技术,2014,42(1):55-59,79. DENG Jun,LI Bei,LI Zhen-bao,et al.Experiment study on gas indexes optimization for coal spontaneous combustion prediction[J].Coal Science and Technology,2014,42(1):55-59,79.
[3] Aaroglu O,Ergin H.A new method to evaluate roadheader operational stability[J].Tunnelling and Underground Space Technology,2006(21):172-179.
[4]Song Z,Kuenzer C.Coal fires in China over the last decade:a comprehensive review[J].International Journal of Coal Geology,2014,133:72-99.
[5]李 林,陈军朝,姜德义,等.煤自燃全过程高温区域及指标气体时空变化实验研究[J].煤炭学报,2016,41(2):444-450. LI Lin,CHEN Jun-chao,JIANG De-yi,et al.Experimental study on temporal variation of high temperature region and index gas of coal spontaneous combustion[J].Journal of China Coal Society,2016,41(2):444-450.
[6]仲晓星,王德明,尹晓丹.基于程序升温的煤自燃临界温度测试方法[J].煤炭学报,2010,35(8):128-131. ZHONG Xiao-xing,WANG De-ming,YIN Xiao-dan.Test method of critical temperature of coal spontaneous combustion based on the temperature programmed experiment[J].Journal of China Coal Society,2010,35(8):128-131.
[7]鲁军辉.煤田火区煤岩体热物性参数及热破坏特性研究[D].西安:西安科技大学,2016. LU Jun-hui.Research on thermal physical parameters and destruction characteristics of coal and rock of coalfield fire area[D].Xi'an:Xi'an University of Science and Technology,2016.
[8]Gosset D,Guillois O,Papoular R.Thermal diffusivity of compacted coal powders[J].Carbon,1996,34(3):369-373.
[9]陈清华,张国枢,关维娟,等.松散煤体热物性参数测试系统的设计与开发[J].煤炭科学技术,2009(2):86-89. CHEN Qing-hua,ZHANG Guo-shu,GUAN Wei-juan,et al.Design and development of thermophysic performance parameter measurement system for bulk coal[J].Coal Science and Technology,2009(2):86-89.
[10]李建伟,葛岭梅,徐精彩,等.松散煤体导热系数测定实验[J].辽宁工程技术大学学报,2004,23(1):6-8. LI Jian-wei,GE Ling-mei,XU Jing-cai,et al.Determination of thermal conductivity of loose coal[J].Journal of Liaoning Technical University,2004,23(1):6-8.
[11]唐明云,张国枢,张朝举,等.平行热线法测定松散煤体导热系数试验[J].矿业安全与环保,2006.33(5):13-15. TANG Ming-yun,ZHANG Guo-shu,ZHANG Chao-ju,et al.Measurement of thermal conductivity of loose coal by parallelhot-wire method[J].Mining Safety and Environmental Protection,2006,33(5):13-15.
[12]Zhumagulov M G.Experimental study of thermophysical properties of Shubarkol coal[J].Chemistry and Technology of Fuels and Oils,2013,49(2):100-107.
[13]Deng J,Li QW,Xiao Y,et al.Experimental study on the thermal properties of coal during pyrolysis oxidation,and reoxidation[J].Applied Thermal Engineering,2017,110:1137-1152.
[14]Guan W,Chen Q,Xu M,et al.Analysis on influential factors of loose coal thermal conductivity test accuracy[J].International Journal of Mining and Mineral Engineering,2014,5(2):106-116.
[15]Liu X,Wang G,Pan G,et al.Numerical analysis of heat transfer and volatile evolution of coal particle[J].Fuel,2013,106:667-673.
[16]Wen H,Lu J,Xiao Y,et al.Temperature dependence of thermal conductivity,diffusion and specific heat capacity for coal and rocks from coalfield[J].Thermochimica Acta,2015,619:41-47.
[17]Parker W J,Jenkins R J.Thermal conductivity measurements on bismuth telluride in the presence of a 2 MeV electron beam[J].Advanced Energy Conversion,1962(2):87-103.
[18]Cowan R D.Proposed method of measuring thermal diffusivity at high temperatures[J].Journal of Applied Physics,1961,32(7):1363-1370.
[19]Cowan R D.Pulse method of measuring thermal diffusivity at high temperatures[J].Journal of Applied Physics,1963,34(4):926-927.
[20]Mostafa M,Afify N,Gaber A,et al.Investigation of thermal properties of some basalt samples in Egypt[J].Journal of Thermal Analysis and Calorimetry,2004,75(1):179-188.
[21]Abdulagatov I M,Abdulagatova Z Z,Kallaev S N,et al.Thermal-diffusivity and heat-capacity measurements of sandstone at high temperatures using laser flash and DSC methods[J].International Journal of Thermophysics,2015,36(4):658-691.
[22]张嬿妮.煤氧化自燃微观特征及其宏观表征研究[D].西安:西安科技大学,2012. ZHANG Yan-ni.Study on the microcosmic characteristics and macro parameters in the process of coal oxidation and spontaneous combustion[D].Xi'an:Xi'an University of Science and Technology,2012.
[23]Maloney D J,Sampath R,Zondlo J W.Heat capacity and thermal conductivity considerations for coal 5 particles during the early stages of rapid heating[J].Combustion and Flame,1999,116:94-104.
[24]谢振华,金龙哲,宋存义.程序升温条件下煤炭自燃特性[J].北京科技大学学报,2003,25(1):12-14. XIE Zhen-hua,JIN Long-zhe,SONG Cun-yi.Coal spontaneous combustion characteristics at programmed temperatures[J].Journal of University of Science and Technology Beijing,2003,25(1):12-14.

相似文献/References:

[1]邓 军,李 贝,肖 旸,等.基于热重-傅里叶红外光谱联用的煤矸石自燃特性及微观表征[J].西安科技大学学报,2017,(01):1.[doi:10.13800/j.cnki.xakjdxxb.2017.0101]
 DENG Jun,LI Bei,XIAO Yang,et al.Spontaneous combustion characteristics and micro characterization of coal gangue based on thermogravimetry- fourier tromsform infrared spectrometer[J].Journal of Xi'an University of Science and Technology,2017,(03):1.[doi:10.13800/j.cnki.xakjdxxb.2017.0101]
[2]冯仗伟,屈永利,袁晓翔,等.澄合矿区东西区5#煤层自燃性能对比实验[J].西安科技大学学报,2011,(04):388.
 FENG Zhang-wei,QU Yong-li,YUAN Xiao-xiang,et al.Study on spontaneous combustion characteristics of coal sample 5# from Chenghe mining area by programmed temperature experiment[J].Journal of Xi'an University of Science and Technology,2011,(03):388.

备注/Memo

备注/Memo:
收稿日期:2017-04-11 责任编辑:刘 洁
基金项目:国家自然科学基金(51204136); 中国博士后科学基金(2016M590963); 陕西省工业科技攻关项目(2016GY-192)
通信作者:肖 旸(1979-),男,贵州湄潭人,博士,教授,E-mail:xiaoy9887@sohu.com
更新日期/Last Update: 2018-06-30