[1]刘文永,文 虎,闫旭斌.煤自然发火过程温度、氧浓度的时空演化规律[J].西安科技大学学报,2017,(05):636-642.[doi:10.13800/j.cnki.xakjdxxb.2017.0506]
 LIU Wen-yong,WEN Hu,YAN Xu-bin.Spatial-temporal variation of temperature and oxygen concentration in coal spontaneous combustion process[J].Journal of Xi'an University of Science and Technology,2017,(05):636-642.[doi:10.13800/j.cnki.xakjdxxb.2017.0506]
点击复制

煤自然发火过程温度、氧浓度的时空演化规律(/HTML)
分享到:

西安科技大学学报[ISSN:1672-9315/CN:61-1434/N]

卷:
期数:
2017年05期
页码:
636-642
栏目:
出版日期:
2017-09-30

文章信息/Info

Title:
Spatial-temporal variation of temperature and oxygen concentration in coal spontaneous combustion process
文章编号:
1672-9315(2017)05-0636-07
作者:
刘文永12文 虎12闫旭斌12
1.西安科技大学 安全科学与工程学院,陕西 西安 710054; 2.陕西省煤火灾害防治重点实验室,陕西 西安 710054
Author(s):
LIU Wen-yong12WEN Hu12YAN Xu-bin12
1.College of Safety Science and Engineering,Xi'an University of Science and Technology,Xi'an 710054,China; 2.Shaanxi Key Laboratory of Prevention and Control of Coal Fire,Xi'an 710054,China
关键词:
自然发火 高温点 氧浓度分布 温度分布 耦合作用
Keywords:
Key words:spontaneous combustion high temperature point oxygen concentration distribution temperature distribution coupling effect
分类号:
TD 75+2
DOI:
10.13800/j.cnki.xakjdxxb.2017.0506
文献标志码:
A
摘要:
为研究煤自然发火过程不同区域的动态发展规律,使用大型煤自然发火实验台测试松散煤体在恒风量条件下从常温至140 ℃的氧化过程,分析了温度、氧浓度在时间及空间上的变化规律。结果表明:松散煤体自燃过程温度随煤体高度的变化在不同温度阶段趋势差异较大,高温点由煤体中部位置向着进风侧方向移动; 不同煤体高度温度与时间呈现指数增长,70 ℃前后煤体呈现缓慢和快速增长分阶段特性; 松散煤体进风口和出气口两侧氧体积分数18%以上,温度超过70 ℃后,不同煤体高度的氧浓度随时间增长逐渐下降。
Abstract:
Abstract:In order to study the dynamic development law of coal spontaneous combustion process in different regions,large-scale coal spontaneous combustion experiment was used to test oxidation process of loose coal under the condition of constant air volume from room temperature to 140 ℃.The changes of temperature and oxygen concentration in time and space were analyzed.The temperature varied greatly with the change of coal height at different temperature phase of loose coal spontaneous combustion process.High temperature point moves from middle part of the coal body to the inlet side.In different coal height the temperature and time increased exponentially.When the maximum temperature reaches 70 ℃,loose coal showed slow and rapid growth phase characteristics.The oxygen volume fraction of loose coal from the air inlet and outlet sides is above 18%,after the temperature exceeds 70 ℃,the oxygen volume fraction of different coal height decreases with the increase of time.

参考文献/References:

[1] 邓 军,李 贝,王 凯,等.我国煤火灾害防治技术研究现状及展望[J].煤炭科学技术,2016,44(10):1-7. DENG Jun,LI Bei,WANG Kai,et al.Research status and outlook on prevention and control technology of coal fire disaster in China[J].Coal Science and Technology,2016,44(10):1-7.
[2] 陈晓坤,李海涛,王秋红,等.高温松散煤体自吸氧试验装置研制及应用[J].中国安全科学学报,2015,25(10):29-34. CHEN Xiao-kun,LI Hai-tao,WANG Qiu-hong,et al.Development and application of experimental device for studying oxygen absorption by high temperature loose coal[J].China Safety Science Journal,2015,25(10):29-34.
[3] 常绪华,王德明,贾海林.基于热重实验的煤自燃临界氧体积分数分析[J].中国矿业大学学报,2012,41(4):526-530. CHANG Xu-hua,WANG De-ming,JIA Hai-lin.Thermogravimetric determination of the critical oxygen volume fraction for spontaneous combustion of coal[J].Journal of China University of Mining and Technology,2012,41(4):526-530.
[4] 张 兵.煤自燃多场耦合的数值模拟[D].西安:西安科技大学,2012. ZHANG Bing.Numerical simulation of coal spontaneous combustion multi field coupling[D].Xi'an:Xi'an University of Science and Technology,2012.
[5] 郑 宁.煤自燃过程中对流扩散反应方程的数值模拟[D].西安:西安科技大学,2006. ZHENG Ning.Numeric approachment of diffusion convection reaction equations and simulation of coal spontaneous combustion[D].Xi'an:Xi'an University of Science and Technology,2006.
[6] 李 林,陈军朝,姜德义,等.煤自燃全过程高温区域及指标气体时空变化实验研究[J].煤炭学报,2016,41(2):444-450. LI Lin,CHEN Jun-chao,JIANG De-yi,et al.Experiment study on temporal variation of high temperature region and index gas of coal spontaneous combustion[J].Journal of China Coal Society,2016,41(2):444-450.
[7] 张 晞,史波波,邵 和,等.变氧浓度下崔家寨矿煤自燃特性的实验研究[J].湖南科技大学学报:自然科学版,2010,25(4):16-20. ZHANG Xi,SHI Bo-bo,SHAO He,et al.Experimental research on coal characteristic of spontaneous combustion under various oxygen concentrations of Cuijiazhai coal[J].Journal of Hunan University of Science and Technology:Natural Science Edition,2010,25(4):16-20.
[8] Wen H,Yu Z J,Deng J,et al.Spontaneous ignition characteristics of coal in a large-scale furnace:An experiment and numerical investigation[J].Applied Thermal Engineering,2017,114:583-592.
[9] 于志金,文 虎,陈晓坤,等.大型煤自燃试验的火源演化特征模拟[J].煤炭科学技术,2017,45(1):89-93. YU Zhi-jin,WEN Hu,CHEN Xiao-kun,et al.Simulation on ignition source evolution features of large scale coal spontaneous combustion experiment[J].Coal Science and Technology,2017,45(1):89-93.
[10]Niu Z Y,Liu G J,Y H,et al,Investigation of mechanism and kinetics of non-isothermal low temperarure pyrolysis of perhydrous bituminous coal by in-situ FTIR[J].Fuel,2016,172(201):1-10.
[11]Niu Z Y,Liu G J,Y H,et al.In-situ FTIR study of reaction mechanism and chemical kinetic of a Xundian lignite during non-isothermal low temperature pyrolysis[J].Energy Conversion and Management,2016,124:180-188.
[12]李 林,陈军朝,姜德义,等.煤自燃全过程高温区域及指标气体时空变化实验研究[J].煤炭学报,2016,41(2):444-450. LI Lin,CHEN Jun-zhao,JIANG De-yi,et al.Experimental study on the high temperature area and indicator gas spatiotemporal change in the whole process of coal spontaneous combustion[J].Journal of Coal Science,2016,41(2):444-450.
[13]周佩玲.采空区遗煤氧化升温时空演化机制研究[D].北京:北京科技大学,2017. ZHOU Pei-ling.Study on space-time evolution mechanism of coal oxide heating in goaf[D].Beijing:Beijing University of Science and Technology,2017.
[14]郑学召,鲁军辉,肖 旸,等.高水分含量对煤自然发火特性参数影响的试验研究[J].安全与环境学报,2014,14(4):71-75. ZHENG Xue-zhao,LU Jun-hui,XIAO Yang,et al.Experiment study over the effect of high moisture on the coal spontaneous combustion characteristic parameters[J].Journal of Safety and Environment,2014,14(4):71-75.
[15]金永飞,闫旭斌,蒋志刚,等.煤仓自然发火过程高温点的运移规律试验研究[J].煤炭科学技术,2016,44(10):34-38. JIN Yong-fei,YAN Xu-bin,JIANG Zhi-gang,et al.Experiment study on high temperature point migration law in coal bunker during coal spontaneous combustion process[J].Coal Science and Technology,2016,44(10):34-38.
[16]仲晓星,王德明,戚绪尧,等.煤自燃倾向性的氧化动力学测定方法研究[J].中国矿业大学学报,2009,38(6):789-793. ZHONG Xiao-xing,WANG De-ming,QI Xu-yao,et al.Research on oxidation kinetics test methods concerning the spontaneous combustion of coal[J].Journal of China University of Mining and Technology,2009,38(6):789-793.
[17]陆 伟,王德明,仲晓星,等.基于活化能的煤自燃倾向性研究[J].中国矿业大学学报,2006,35(2):201-203. LU Wei,WANG De-ming,ZHONG Xiao-xing,et al.Tendency of spontaneous combustion of coal based on activation energy[J].Journal of China University of Mining and Technology,2006,35(2):201-203.
[18]文 虎,徐精彩,李 莉,等.煤自燃的热量积聚及影响因素分析[J].煤炭学报,2003,28(4):370-374. WEN Hu,XU Jing-cai,LI Li,et al.Analysis of coal self-ignite heat accumulating process and its effect factor[J].Journal of China Coal Society,2003,28(4):370-374.
[19]徐精彩.煤自燃危险区域判定理论[M].北京:煤炭工业出版社,2001. XU Jing-cai.Determination theory of coal spontaneous combustion zone[M].Beijing:China Coal Industry Press,2001.
[20]马汉鹏,陆 伟,王德明,等.煤自燃过程物理吸附氧的研究[J].煤炭科学技术,2006,34(7):26-29.

相似文献/References:

[1]徐杨,周延.煤自然发火预报的人工神经网络模型[J].西安科技大学学报,2009,(04):410.[doi:10.13800/j.cnki.xakjdxxb.2009.04.014]

备注/Memo

备注/Memo:
基金项目:陕西省基础研究计划(2016JM5022) 通讯作者:刘文永(1986-),男,河北保定人,工程师,E-mail:liuwenyong1688@163.com
更新日期/Last Update: 2017-11-08